Kawasaki Jet Ski, 1992-1994 W802

Kawasaki Jet Ski, 1992-1994
Page Count:0
Copyright:1995
UPC Code:024185764410
ISBN: 9780892876440

Item ID:W802




DESCRIPTIONMODELS COVERED
CHAPTER ONE / GENERAL INFORMATION

CHAPTER TWO / TROUBLESHOOTING

CHAPTER THREE / LUBRICATION, MAINTENANCE AND TUNE-UP
Operational check list / Lubrication / Recommended fuel mixture / Fuel mixing / Starter gear oil / Control cable lubrication / Periodic maintenance / Fuel vent check valve inspection / Oil tank vent valve / fuel filter / Flame arrester / Impeller / Rubber coupler / On-shore cooling / Steering cable adjustment / Trim cable adjustment / Throttle cable adjustment / Choke cable adjustment / Engine tune-up / Retorque cylinder head / Compression test / Spark plug / Ignition timing / Carburetor adjustment / Fuel mixture screw initial setting / Fuel mixture adjustment / idle speed / Carburetor synchronization / Storage / Specifications

CHAPTER FOUR / ENGINE (440 AND 550 CC)
Engine lubrication / Service precautions / Serial numbers / Servicing engine in hull / Removal installation / Engine top end / Cylinder / Piston, pin and rings / Crankcase and crankshaft / Specifications

CHAPTER FIVE / ENGINE (650 AND 750 CC)
Engine lubrication / Service precautions / Serial numbers / Servicing the engine in the hull / Engine / Engine top end / Cylinder / Piston, pin and rings / Reed valve assembly / Crankcase and crankshaft / Water drain valve / Starter reduction gear / Specifications

CHAPTER SIX / DRIVE TRAIN
Drive shaft / Jet pump / Reverse system / Specifications

CHAPTER SEVEN / FUEL AND EXHAUST SYSTEMS
Flame arrestor / Mikuni carburetor / Keihin carburetor / Fuel pump / Fuel tank / Main fuel valve / Exhaust system / Exhaust system cleaning and inspection / Specifications

CHAPTER EIGHT / ELECTRICAL SYSTEMS
Battery / Charging system / Electric starting system / Capacitor discharge ignition CDI / RPM limiter / Electric box / Bilge pump test / Bilge blower / Temperature sensor switch / Stop and start switches / Specifications

CHAPTER NINE / OIL INJECTION SYSTEM
Oil pump service / Oil tank / Oil level sensor / Oil tank check valve / Oil pump / Specifications

CHAPTER TEN / BILGE SYSTEM
Vacuum-type bilge system / Electric bilge system / Specifications

CHAPTER ELEVEN / STEERING AND HULL REPAIR
Steering assembly / Trim adjuster / Hull repair / Deck frame / Specifications

INDEX

WIRING DIAGRAMS

1992-1994 KAWASAKI JB650 Jet Mate
1992 - 1994 KAWASAKI JF650TS
1992-1994 KAWASAKI JF650X2
1992-1994 KAWASAKI JH750 Super Sport Xi
1992-1994 KAWASAKI JH750SS
1992-1994 KAWASAKI JH750XiR
1992-1994 KAWASAKI JL650SC
1992-1994 KAWASAKI JS440SX
1992-1993 KAWASAKI JS550SX (B Models with Piston Port Engines)
1992-1994 KAWASAKI JS650SX
1992-1994 KAWASAKI JS750SX
1992-1994 KAWASAKI JT750ST